|
|
|
|
|
|
|
|
|
|
|
All capacitors have a certain amount of resistance to the passage of AC current. ESR (Equivalent Series Resistance) is the sum of all internal resistances of a capacitor measured in Ohms. An ideal capacitor has ZERO ohms ESR. From the diagram below you can see a resistor in series with a "PERFECT CAPACITOR". The value of the resistor is called ESR. Electrolytic Capacitors have a tendency to increase its ESR overtime due to drying or corrosion. High ESR is a frequent problem in today's electronic circuit. Even a 1 or 2 ohms rise in ESR can cause complicated problems. Under normal conditions the ESR has a very low value, which stays that way for many years unless the rubber seal is defective, in which case the electrolyte's water component gradually dries out and the ESR creeps up with time. The increase in ESR increases both voltage drops within the capacitor and the heat, produced in the capacitors due to resistive heating. If you don't check for ESR, you may be in for a "TOUGH DOG" repair. High ESR is the first sign of a capacitor failure. High ESR will cause complete circuit failure, over heating of capacitor, loading of the circuit, overstressing of other circuit components and other undesirable effects.
Why should I use an ESR?
Because measuring an electrolytic capacitor with an analog or digital capacitance meter can MISLEAD a technician into believing that a defective capacitor is good. This can waste your precious time and you are unable to repair the equipment. Which means you can't charge your customer! If you don't test for ESR on the capacitor, you will always miss the bad capacitor. Normally, these bad capacitors have high ESR reading which your normal multimeter or digital capacitance meter can't measure. Only by using the ESR meter, you will be able to measure the ESR on the capacitor and you will not be fooled by capacitors with bad ESR. ESR meter can even work IN-CIRCUIT, which means you don't have to solder out the capacitor in order to measure it using normal capacitor tester, which would not be accurate anyway.
Do you know that ESR meters can perform other wonders besides checking the ESR of a capacitor? Some digital ESR meter have the features of checking:
» Low ohms resistor such as 0.22 ohm, 0.33 ohm and etc.
» Horizontal yoke coil winding of a picture tube, inductor and primary winding of a transformer ? If a shorted turn is present, the inductance drops dramatically and the meter will show the ohms reading.
» Horizontal output transistor (HOT) in a monitor or TV ? If an open-circuit reading is obtained, the short-circuit is elsewhere. If the short-circuit remains, the transistor is faulty.
» Short-circuit in the track, usually trace to the components - You can use the ESR meter to locate short-circuits on printed circuit boards by measuring the actual track resistance. If the reading increases as you probe further along the track, you know you're going in the wrong direction!
» Speakers, amplifier etc - The pulses have a fast rise/fall time, so it would probably make a crude RF signal injector as well.
» The condition of both the normal and rechargeable batteries ? Flat and faulty battery will have high ESR.
Jestine Yong is a electronic repairer and writer. For more information about electronic repair please visit his website at http://www.noahtec.com
Used laptop computers are everywhere these days. How can you... Read More
Take a good look at your notebook computer screen. Do... Read More
Roll over lumbering desktop computers, the limber laptop is here,... Read More
You are working and trying to print out important documents... Read More
What is so important about cables anyway?One of the most... Read More
The Crooked E: The Unshredded Truth About Enron is a... Read More
If you have not seen the newest addition to the... Read More
Someone recently asked me "I teach senior citizens in a... Read More
CCNA and CCNP candidates hear it all the time: "you... Read More
In electronic repair, most of the time i came across... Read More
RAID is short for Redundant Array of Independent (or Inexpensive)... Read More
What is Video Encryption?Video Encryption is an extremely useful method... Read More
So many people have small USB drives today, but what... Read More
It is extremely important not to make or write any... Read More
So you bought a new computer but you don't have... Read More
This is the first article in the Understanding Your Computer... Read More
Perhaps the biggest mistake people make when building their computer(s)... Read More
The power coming into a computer is the most critical... Read More
Ever wonder where all the cool gadgets come from? Ever... Read More
Video displays are most recent technique used in both outdoor... Read More
Years ago computers were huge and their accompanying printers were... Read More
There are three refurbished laptop battery types, each named for... Read More
The notebook computer is coming of age. For the first... Read More
When you work in an office, it's important to lock... Read More
Getting a new PC is exciting and a pain. It's... Read More
So you know a little bit about tape backup, but... Read More
Notebook Computers Are Sexy!Granted, the notebook computer may just be... Read More
Picking your way through the ton of information available on... Read More
If, for some reason, you can't get an exact replacement... Read More
1. Pocket DVD Wizard http://www.deprice.com/pocketdvdwizard.htmThe Pocket DVD Wizard allows you... Read More
Soon the human brain will be completely interfaced with the... Read More
What is so important about cables anyway?One of the most... Read More
Blu-ray is an optical disc format which is set to... Read More
This is the first step to servicing, upgrading or removing... Read More
There are many fancy add-ons for computers, but the basic... Read More
HP refurbished laptops can be found on their website hpshopping.com.... Read More
Nothing is completely safe today. Adobe has recently released a... Read More
Nowadays, more and more monitor comes in with flyback transformers... Read More
Used laptop computers are everywhere these days. How can you... Read More
Digital cameras have really taken off in popularity in recent... Read More
The notebook computer is coming of age. For the first... Read More
Thinking about a mini DVD camcorder? You're not alone, it's... Read More
Someone recently asked me "I teach senior citizens in a... Read More
High definition DVD, also known as HD-DVD (which actually stands... Read More
MMC and SDFlash memory is available in so many formats... Read More
Data Centers are the core of the Internet. The computer... Read More
All in one printers, also known as multifunction printers (MFPs),... Read More
Things to Consider When Choosing a Computer CaseIn the past,... Read More
Are you sick of viewing everything on that small screen... Read More
Q : What is over clocking?Overclocking is when you make... Read More
Computer Hardware |